| Home | E-Submission | Sitemap | Editorial Office
top_img
Journal of Korean Neurosurgical Society > Volume 60(4); 2017 > Article
Cho, Kang, Cho, Choi, Jeon, and Yang: Osteoblast and Bacterial Culture from Cryopreserved Skull Flap after Craniectomy: Laboratory Study

Abstract

Objective

Cranioplasty using a cryopreserved skull flap is a wide spread practice. The most well-known complications of cranioplasty are postoperative surgical infections and bone flap resorption. In order to find biological evidence of cryopreserved cranioplasty, we investigated microorganism contamination of cryopreserved skulls and cultured osteoblasts from cryopreserved skulls.

Methods

Cryopreserved skull flaps of expired patients stored in a bone bank were used. Cryopreserved skulls were packaged in a plastic bag and wrapped with cotton cloth twice. After being crushed by a hammer, cancellous bone between the inner and outer table was obtained. The cancellous bone chips were thawed in a water bath of 30°C rapidly. After this, osteoblast culture and general microorganism culture were executed. Osteoblast cultures were done for 3 weeks. Microorganism cultures were done for 72 hours.

Results

A total of 47 cryopreserved skull flaps obtained from craniectomy was enrolled. Of the sample, 11 people were women, and the average age of patients was 55.8 years. Twenty four people had traumatic brain injuries, and 23 people had vascular diseases. Among the patients with traumatic brain injuries, two had fracture compound comminuted depressed. The duration of cryopreservation was, on average, 83.2 months (9 to 161 months). No cultured osteoblast was observed. No microorganisms were cultured.

Conclusion

In this study, neither microorganisms nor osteoblasts were cultured. The biological validity of cryopreserved skulls cranioplasty was considered low. However, the usage of cryopreserved skulls for cranioplasty is worthy of further investigation in the aspect of cost-effectiveness and risk-benefit of post-cranioplasty infection.

INTRODUCTION

The most effective surgical method for increased intracranial pressure not responding to medical treatments is craniectomy, and the skull flap obtained from craniectomy is either cryopreserved or banked in a subcutaneous pocket in the patient’s abdominal wall3,4,7,18,24,36).
Cranioplasty using a patient’s autologous cryopreserved skull flap is a widespread practice across the world. The merits of using cryopreserved skull flaps are its inexpensive cost and cosmetically natural output21). The most well-known complications of cranioplasty are postoperative surgical infections and bone flap resorption33). Bhaskar reported “bone flap non-viability may be a contributing factor” of these complications6). For this reason, there are many opportunities to test and see the viability of cryopreserved skulls6,14,19,28). However, biological evidence of cryopreserved auto-bone cranioplasty is obscure.
Cranioplasty with an autologous fresh skull flap leads to very strong bony fusion. The osteogenic, osteoinductive and osteoconductive materials are rich in fresh bone flap. However, whether these three components are present in a cryopreserved skull flap remains uncertain. There are few reports on the osteogenic potential of a cryopreserved skull flap. It has been reported that osteoblasts were not cultured from skull flaps cryopreserved for more than 6 months6). There are very few reports regarding the fate of a transplanted cryopreserved skull. Would the cryopreserved skull become a transplanted organ or just be a histocompatible scaffold containing osteoinductive and osteoconductive materials?
The prime objective of this study was to find biological evidence of cranioplasty with autologous cryopreserved skull flaps. The first step was to extract viable cells from cryopreserved skulls. In this study, we tried to extract osteoblasts, an essential cellular component of osteogenesis, from cryopreserved skull flaps. The other objective was to investigate microorganism contamination while thawing the skull, a process that may cause post-cranioplasty infection.

MATERIALS AND METHODS

The bone flaps from decompressive craniectomy were stored in a freezer with a temperature of −70°C. Before cryopreservation, the bone flaps were packaged in a plastic vinyl bag and packaged two more times with sterile cotton cloths. The skull flaps were collected from expired patients, and this protocol was conducted after receiving deliberations of Institutional Review Board (2015-123).
The cryopreserved bone flap packages were crushed with a hammer and the resulting bone fragments were used. Using sterile surgical instruments, cancellous bone between the inner and outer table was obtained. The cancellous bone chips were put into sterile phosphate buffer saline (PBS) and thawed in a water bath of 30°C for 10 minutes. After this thawing process, osteoblasts culture and general microorganism culture from bone chips were executed (Fig. 1A).
We followed bone explant methods as reported by Bhaskar et al.6) “For bone explant cultures, the bone samples were initially rinsed with sterile PBS and transferred to a clean dish containing 2 mL to 3 mL of PBS. The bone samples were further diced into pieces measuring approximately 3 mm in maximal dimensions. After decanting the PBS, the bone chips were transferred to a sterile 50 mL tube with 15 mL to 20 mL of PBS and placed in a vortex mixer for 30 seconds. The supernatant was then decanted and the process repeated to wash off marrow and fat debris. The washed bone fragments were cultured as explants at a density of 0.2-0.6 gm of tissue/100 mm dish in 10 mL of Dulbecco’s Modified Eagle’s medium enriched with 10% fetal bovine serum, 100 L/mL penicillin and 100 μg/mL streptomycin and incubated at 37°C in 5% carbon dioxide (CO2). These cultures were maintained undisturbed for 7 days, following which the culture medium was replaced with an equal volume of fresh complete medium, taking care not to dislodge the explants. After 14 days, the medium was changed twice weekly thereafter. This process was repeated and the cultures were subjected to microscopic examination for presence of cell growth at 7 days, 14 days, and 21 days.” (Fig. 1B).
To confirm osteoblast culture, alkaline phosphatase (ALP) staining was performed with leukocyte alkaline phosphatase kit (Sigma Aldrich, St Louis, MO, USA). The culture media was aspirated and washed with PBS. Cells were fixed with 0.5 mL citrate, 1.3 mL acetone and 0.16 mg formaldehyde solution at room temperature for 1 minute. After fixative removal, the prepared staining solution with a water buffer was added to cover the plate. After covering the plate with foil, the cells were incubated for 15 minutes. The plate was rinsed with PBS twice. ALP-positive cells showed purple or red stains under microscopic examination (Fig. 1C).
For microorganism cultures, MacConkey agar plates, Chocolate agar plates and Sabouraud Dextrose agar plates were used in 37°C. For 72 hours, the colony cultures were observed.

RESULTS

A total of 47 cryopreserved skull flaps obtained from craniectomy between August 2002 and May 2015 was enrolled. Of the sample, 11 people were women, and the average age of patients was 55.8 years at the time of surgery. Twenty three patients had vascular diseases, and 24 patients had traumatic brain injuries. Among the patients with traumatic brain injuries, 2 patients had open fractures. From surgery to thawing, the average cryopreservation period was 83.2 months. The shortest period was 9 months and longest period was 161 months. During 21 days of observation, no cell growth from cryopreserved skull flap was observed. No microorganisms were cultured.

DISCUSSION

In this study, we attempted to extract osteoblasts and culture the microorganisms from cryopreserved skull flaps obtained from decompressive craniectomy. We used the skull flaps of 47 patients; however, neither osteoblasts nor microorganisms were cultured.

Cranioplasty and bone flap cryopreservation after decompressive craniectomy

Decompressive craniectomy is a traditional, classic and evidence-based surgical method for intractable increased intracranial pressure4). Cranioplasty after decompressive craniectomy is an essential and classic surgical method; we can even find evidence of the ancient Incan civilization practicing cranioplasty from historical records. The increase of decompressive craniectomy is leading to an increase in cranioplasty9).
The reason why we should perform cranioplasty after craniectomy is to protect the brain, achieve a natural appearance and prevent sinking skin flap syndrome (or syndrome of the trephined). Furthermore, cranioplasty may improve neuronal function after craniectomy. Many documents report cranioplasty enhances cerebral glucose metabolism, cerebrovascular reserve capacity, postural blood flow regulation and cerebrospinal fluid circulation8,9,12). Clinically, cranioplasty improves cortical perfusion23). In animal study, these phenomena are reproduced17).
How was the skull flap preserved sterilely after craniectomy? There are various methods to sterilize autologous skull flaps for cranioplasty, such as subcutaneous layer placing, cryopreservation or dumping1,2,18,25). The advancements in freezing technology allows cryopreservation to become a more economic and practical method; the most noteworthy development being the deep-freezer11). Biomechanical studies reveal that the freezing and thawing processes have little effect on the mechanical properties of the human skull35). However, there is not a lot of information on how to cryopreserve skull flaps. There is no protocol for bone flap cryopreservation. According to Bhaskar, 96% of 25 neurosurgical centers in Australia have been using cryopreserved autologous bone flaps for cranioplasty7). In his report, 88% of institutions used double or triple bagged under dry, sterile conditions for packing bone flaps. The bone flaps were cryopreserved at between −18°C and −83°C7).

What happens after cranioplasty and why were osteoblasts not extracted in this study?

The fresh bone flap is usually reinserted immediately after craniotomy. Reinserted bone flaps undergo complex healing processes to fuse with surrounding bones29). Capillary invasion and osteoblast migration from surrounding bones are important for the bone flap’s survival. After reinsertion, no blood is supplied to the bone flap, leading to ischemia. The bone flap is surrounded by blood and inflammatory response is initiated. Capillaries from surrounding bone, dura and periosteum infiltrate the reinserted bone. As granulation tissue proliferates, capillaries invade the reinserted bone flap. Through the capillary, primitive progenitor cell migrates and bone remodeling occurs5). Necrotic bone is gradually reabsorbed. If this functional contact between the reinserted flap and surrounding bone is poor, the reinserted flap will be absorbed, partially or totally (Fig. 2)29). In an animal study, free skull flaps showed a 50% reduction in volume after reinsertion13). Similarly, an experimental study on cranioplasty using bone particles also showed that half of the on-lay graft is reabsorbed10).
After decompressive craniectomy, bone flap reinsertions were delayed. Bone flaps were stored in abdominal subcutaneous pockets or were cryopreserved. Oh et al, reported that special freezing techniques were required to maintain osteoblast viability in frozen human iliac cancellous bone24). Simpson reported 3.1% of osteoblast-like cell cultures from frozen cancellous bones were harvested from femoral head and stored for more than 6 months31). However, the osteogenic capacity of skull is markedly deficient than that of long bone29). Furthermore, cell damage occurs during the freezing and thawing procedures24). Some reports recommend bone flap cryopreservation with glycerol, known as cryoprotectant solutions30,34). In another animal study, a specifically programmed freezer is required for cranial bone regeneration from a cryopreserved skull19). We recommend that operators reduce the gap between cryopreserved flaps and viable skulls to encourage osteogenic progenitor cell migration to reduce bone resorption. Wider contact surface would be promoting osteogenic progenitor cell migration from the host skull to the cryopreserved flap, which has rich histocompatible osteoinductive and osteoconductive materials. We think that periosteum preservation during craniectomy and cranioplasty is also important to promote bone fusion between the cryopreserved flap and the host skull.
We believe there were several reasons why osteoblasts were not extracted in this study. The average age of enrolled patients was 55.8 years (min 20, max 87), having a relatively low regeneration power. The cryopreservation period was longer than 6 months. There was little cancellous bone marrow in the skull flap rather than femoral heads31). There were no special cryopreservation protocols such as cryopreservation time interval from bone flap extraction to cryopreservation, deep freezing technique, duration, and cryoprotectant use.
In this study, no culture of an osteoblast was the same as in the Bhaskar’s study6), and we think it is meaningful to reproduce the existing negative results. And Bhaskar’s study6) had 27 samples, but the number of samples in this study was 47, and the cryopreservation was frozen at −30 degrees in Bhaskar’s paper6), but we kept it at −70 degrees. In addition, this paper differs from previous papers in that it performed not only osteoblast cell culture but also bacterial culture. The use of non-viable tissue as well as contamination in relation to postoperative infection may be a bigger problem. However, after reviewing published papers, we think that it is difficult to conclude that the cryopreserved skull is a non-viable tissue. Therefore, it would be meaningful to suggest that the bacterium was not cultured in the cryopreserved skull.

Economics of cryopreserved skull flap22)

Cryopreserved skull flaps have osteoinductive and osteoconductive characters biologically. If we could extract osteoblasts from cryopreserved skull flaps, we can prove this is an ideal material for cranioplasty. We think cranioplasty with cryopreserved autologous skulls is valuable in two aspects.
First, biologically cryopreserved skull flaps are the best scaffold for autologous osteoblasts. In the concept of tissue-engineered constructs, cryopreserved skull flaps are filled with osteoconductive and osteoinductive materials, which were completely matched with the recipient immunologically20). Cryopreserved skulls are the most ideal substitute for cranioplasty.
Seconds, the cryopreserved skull flaps are economic. There are many reports about new substitute for cranioplasty, recently21,22,26,27,32). The difference of the clinical outcome between synthetic materials and autologous bone graft in cranioplasty is very small. Some authors report lower complication with synthetic materials7,25-28). Many researchers emphasize the economic merit of cranioplasty with autologous cranioplasty15,21,22). However, opposing viewpoints do exist, such as reports from USA & Canada that report the total cumulative cost, including possible complication treatments between titanium cranioplasty and autologous cranioplasty, was not significantly different16,34). It is only natural that the surgical cost of cranioplasty is different in each country because the medical service systems are different. In the Republic of Korea, cranioplasty using synthetic materials is three times more expensive than cranioplasty using a cryopreserved skull. Thus, cranioplasty using cryopreserved skull flaps is more economic than synthetic materials in Republic of Korea.
In this study, the minimum duration of cryopreservation was 9 months. If there were bone flaps cryopreserved for periods shorter than 6 months, the result may have been different. However, we maintain that the possibility of osteoblast extraction would still be very low, even if the cryopreservation period was shorter than 6 months because there was no report about osteoblast explant from cryopreserved skull in human study. Unfortunately, we could not find any reports on the regenerative potential of skulls. However, we know that the skull has an inner and outer cortical table, and the cancellous bone between them is very small. As patients get older, the hematopoietic potentials of bone marrow decrease. Most patients are adults, not children.

CONCLUSION

In this study, neither microorganisms nor osteoblasts were cultured. On the positive side, no evidence of frozen skull contamination, even during the thawing process, was found. No cultured osteoblasts were found in the cryopreserved skulls. The biological validity of using cryopreserved skulls for cranioplasty was considered low. However, the usage of cryopreserved skulls for cranioplasty is worthy of further investigation in the aspect of cost-effectiveness and risk-benefit of post-cranioplasty infection.

Acknowledgements

This study was supported by BioGreen21 Program (PJ01121401) of Rural Development Administration of ROK. This work was supported by a grant from Hallym University Medical Center Research Fund (HURF 2015-42).
We are thankful to Chi Hern Lee and Noar Kim who provided expertise that greatly assisted the research.

Fig. 1
Osteoblast extraction method from cryopreserved skull. A: The cryopreserved skull flap packages were crushed by hammer and bone fragments were used. Using sterile surgical instrument, cancellous bone between inner and outer table was obtained. B: Low power field polarization microscopic examintaion 21 days after culture showed abundant spindle-like cells around bone chips (×40). C: High power field microscopic examination with alkaline phosphatase staining showed purple colored stained cell as described in the Materials and Methods sections (ALP staining, ×200).
jkns-60-4-397f1.gif
Fig. 2
Schematic figure of bone fusion process after craniotomy. A: Inflammatory phase. The bone flap is surrounded by blood and inflammatory response is initiated. (Top to bottom) Capillaries from surrounding bone, dura and periosteum infiltrate to the transplanted bone. As granulation tissue proliferated, capillaries invade the transplanted bone flap. Through the capillary, primitive progenitor cell migrated and bone remodeling occurred. If this functional contact between the transplanted flap and surrounding bone is poor, re-inserted bone flap would be in ischemic necrosis, and be absorbed. B: Callus formation phase. Cartilage and fibrous tissue is laid down and make new lamellar bone, which is remodeled with osteoclast-osteoblast coupling activity to strong bone fusion.
jkns-60-4-397f2.gif

References

1. Abbott KH : Use of frozen cranial bone flaps for autogenous and homologous grafts in cranioplasty and spinal interbody fusion. J Neurosurg 10 : 380-388, 1953
crossref pmid
2. Asano Y, Ryuke Y, Hasuo M, Simosawa S : Cranioplasty using cryopreserved autogenous bone. No To Shinkei 45 : 1145-1150, 1993
pmid
3. Baldo S, Tacconi L : Effectiveness and safety of subcutaneous abdominal preservation of autologous bone flap after decompressive craniectomy: a prospective pilot study. World Neurosurg 73 : 552-556, 2010
crossref pmid
4. Barthelemy EJ, Melis M, Gordon E, Ullman JS, Germano IM : Decompressive craniectomy for severe traumatic brain injury: a systematic review. World Neurosurg 88 : 411-420, 2016
crossref pmid
5. Benzel EC, Gilbertson L, Mericle RA : Enhancing spinal fusion. Clin Neurosurg 55 : 63-71, 2008
pmid
6. Bhaskar IP, Yusheng L, Zheng M, Lee GY : Autogenous skull flaps stored frozen for more than 6 months: do they remain viable? J Clin Neurosci 18 : 1690-1693, 2011
crossref pmid
7. Bhaskar IP, Zaw NN, Zheng M, Lee GY : Bone flap storage following craniectomy: a survey of practices in major Australian neurosurgical centres. ANZ J Surg 81 : 137-141, 2011
crossref pmid
8. Carvi Y, Nievas MN, Höllerhage HG : Early combined cranioplasty and programmable shunt in patients with skull bone defects and CSF-circulation disorders. Neurol Res 28 : 139-144, 2006
crossref pmid
9. Chaturvedi J, Botta R, Prabhuraj AR, Shukla D, Bhat DI, Devi BI : Complications of cranioplasty after decompressive craniectomy for traumatic brain injury. Br J Neurosurg 30 : 264-268, 2016
crossref pmid
10. Clune JE, Mulliken JB, Glowacki J, Arany PR, Kulungowski AM, Rogers GF, et al : Autologous cranial particulate bone graft: an experimental study of onlay cranioplasty. J Craniofac Surg 22 : 319-323, 2011
crossref pmid
11. Elliott H, Scott H : The bone-bank in neurosurgery. Br J Surg 39 : 31-34, 1951
crossref pmid
12. Erdogan E, Düz B, Kocaoglu M, Izci Y, Sirin S, Timurkaynak E : The effect of cranioplasty on cerebral hemodynamics: evaluation with transcranial Doppler sonography. Neurology India 51 : 479-481, 2003
pmid
13. Fukuta K, Har-Shai Y, Collares MV, Herschman BR, Persiani RJ, Jackson IT : The viability of revascularized calvarial bone graft in a pig model. Ann Plas Surg 29 : 136-142, 1992
crossref
14. Georgiou K, Fan C, Ng Y, Shandala T, King T, Scherer M, et al : Do cryopreserved autogenous cranial bone flaps remain viable at cranioplasty? Bone 47 : S387-S388, 2010
crossref
15. Hayward RD : Cranioplasty: don’t forget the patient’s own bone is cheaper than titanium. Br J Neurosurg 13 : 490-491, 1999
crossref pmid
16. Honeybul S, Morrison DA, Ho KM, Lind CR, Geelhoed E : A randomized controlled trial comparing autologous cranioplasty with custom-made titanium cranioplasty. J Neurosurg 126 : 81-90, 2017
crossref pmid
17. Hwang G, Oh CW, Han JH, Kim CY, Kwon OK, Park SQ, et al : Decompressive craniectomy for malignant middle cerebral infarction. Korean J Cerebrovasc Surg 11 : 49-54, 2009

18. Joaquim AF, Mattos JP, Neto FC, Lopes A, de Oliveira E : Bone flap management in neurosurgery. Revista Neurociencias 17 : 133-137, 2009

19. Kaku M, Koseki H, Kojima S, Sumi H, Shikata H, Kojima S, et al : Cranial bone regeneration after cranioplasty using cryopreserved autogenous bone by a programmed freezer with a magnetic field in rats. Cryo Letters 35 : 451-461, 2014
pmid
20. Kuleshova LL, Gouk SS, Hutmacher DW : Vitrification as a prospect for cryopreservation of tissue-engineered constructs. Biomaterials 28 : 1585-1596, 2007
crossref pmid
21. Lemée JM, Petit D, Splingard M, Menei P : Autologous bone flap versus hydroxyapatite prosthesis in first intention in secondary cranioplasty after decompressive craniectomy: a French medico-economical study. Neurochirurgie 59 : 60-63, 2013
crossref pmid
22. Lethaus B, Bloebaum M, Koper D, Poort-Ter Laak M, Kessler P : Interval cranioplasty with patient-specific implants and autogenous bone grafts--success and cost analysis. J Craniomaxillofac Surg 42 : 1948-1951, 2014
crossref pmid
23. Mah JK, Kass RA : The impact of cranioplasty on cerebral blood flow and its correlation with clinical outcome in patients underwent decompressive craniectomy. Asian J Neurosurg 11 : 15-21, 2016
crossref pmid pmc
24. Oh JH, Zöller JE, Kübler A : A new bone banking technique to maintain osteoblast viability in frozen human iliac cancellous bone. Cryobiology 44 : 279-287, 2002
crossref pmid
25. Osawa M, Hara H, Ichinose Y, Koyama T, Kobayashi S, Sugita Y : Cranioplasty with a frozen and autoclaved bone flap. Acta Neurochir (Wien) 102 : 38-41, 1990
crossref pmid
26. Piitulainen JM, Kauko T, Aitasalo KM, Vuorinen V, Vallittu PK, Posti JP : Outcomes of cranioplasty with synthetic materials and autologous bone grafts. World Neurosurg 83 : 708-714, 2015
crossref pmid
27. Plum AW, Tatum SA : A comparison between autograft alone, bone cement, and demineralized bone matrix in cranioplasty. Laryngoscope 125 : 1322-1327, 2015
crossref pmid
28. Prolo DJ, Burres KP, McLaughlin WT, Christensen AH : Autogenous skull cranioplasty: fresh and preserved (frozen), with consideration of the cellular response. Neurosurgery 4 : 18-29, 1979
crossref pmid
29. Shaffrey ME, Persing JA, Shaffrey CI, Delashaw JB, Jane HA : Management of cranial defect. Edited by Apuzzo MLJ : In: Brain Surgery: complication avoidance and management London, Churchill Livingstone Inc. pp 1373-1400, 1993

30. Shimizu S, Morikawa A, Kuga Y, Mouri G, Murata T : Cranioplasty using autogenous bone cryopreserved with dimethylsulfoxide (DMSO). No Shinkei Geka 30 : 479-485, 2002
pmid
31. Simpson D, Kakarala G, Hampson K, Steele N, Ashton B : Viable cells survive in fresh frozen human bone allografts. Acta Orthop 78 : 26-30, 2007
crossref pmid
32. Stefini R, Zanotti B, Nataloni A, Martinetti R, Scafuto M, Colasurdo M, et al : The efficacy of custom-made porous hydroxyapatite prostheses for cranioplasty: evaluation of postmarketing data on 2697 patients. J Appl Biomater Funct Mater 13 : e136-e144, 2015
crossref pmid
33. Sundseth J, Sundseth A, Berg-Johnsen J, Sorteberg W, Lindegaard KF : Cranioplasty with autologous cryopreserved bone after decompressive craniectomy: complications and risk factors for developing surgical site infection. Acta Neurochir (Wien) 156 : 805-811; discussion 811, 2014
crossref pmid pmc
34. Takeuchi H, Higashino Y, Hosoda T, Yamada S, Arishima H, Kodera T, et al : Long-term follow-up of cryopreservation with glycerol of autologous bone flaps for cranioplasty after decompressive craniectomy. Acta Neurochir (Wien) 158 : 571-575, 2016
crossref pmid pdf
35. Torimitsu S, Nishida Y, Takano T, Koizumi Y, Hayakawa M, Yajima D, et al : Effects of the freezing and thawing process on biomechanical properties of the human skull. Leg Med (Tokyo) 16 : 102-105, 2014
crossref pmid
36. Wang JW, Li JP, Song YL, Tan K, Wang Y, Li T, et al : Decompressive craniectomy in neurocritical care. J Clin Neurosci 27 : 1-7, 2016
crossref pmid
TOOLS
PDF Links  PDF Links
PubReader  PubReader
ePub Link  ePub Link
Full text via DOI  Full text via DOI
Download Citation  Download Citation
CrossRef TDM  CrossRef TDM
  E-Mail
Share:      
METRICS
0
Crossref
0
Scopus
876
View
27
Download
Related article
Editorial Office
#402, 27 Chilparo, Jung-gu, Seoul 04511, Korea
TEL: +82-2-525-7552   FAX: +82-2-525-7554   E-mail: kns61@neurosurgery.or.kr
About |  Browse Articles |  Current Issue |  For Authors and Reviewers
Copyright © Korean Neurosurgical Society. All rights reserved.                 developed in m2community
Close layer
prev next